Chapter NR 666

subch. C of ch. NR 666 Subchapter C — Recyclable Materials Used in a Manner Constituting Disposal

Subch. C of ch. NR 666 Note Note: This subchapter is similar to federal regulations contained in 40 CFR part 266 subpart C, as revised on July 24, 2002

NR 666.020 NR 666.020 Applicability.

NR 666.020(1) (1) This subchapter applies to recyclable materials that are applied to or placed on the land in one of the following ways:

NR 666.020(1)(a) (a) Without mixing with any other substance.

NR 666.020(1)(b) (b) After mixing or combination with any other substance or substances. These materials will be referred to throughout this subchapter as “materials used in a manner that constitutes disposal”.

NR 666.020(2) (2) Products produced for the general public’s use that are used in a manner that constitutes disposal and that contain recyclable materials are not presently regulated if the recyclable materials have undergone a chemical reaction in the course of producing the products so as to become inseparable by physical means and if the products meet the applicable treatment standards in subch. D of ch. NR 668 (or applicable prohibition levels in s. NR 668.32, where no treatment standards have been established) for each recyclable material (i.e., hazardous waste) that they contain, and if the recycler complies with s. NR 668.07 (2) (f).

NR 666.020(3) (3) Anti-skid and deicing uses of slags, which are generated from high temperature metals recovery (HTMR) processing of hazardous waste K061, K062 and F006, in a manner constituting disposal are not covered by the exemption in sub. (2) and remain regulated.

NR 666.020(4) (4) Fertilizers that contain recyclable materials are not regulated if any of the following apply:

NR 666.020(4)(a) (a) They are zinc fertilizers excluded from the definition of solid waste according to s. NR 661.0004 (1) (u).

NR 666.020(4)(b) (b) They meet the applicable treatment standards in subch. D of ch. NR 668 for each hazardous waste that they contain.

NR 666.020 History History: CR 05-032: cr. Register July 2006 No. 607, eff. 8-1-06; CR 19-082: am. (2), (4) (a) Register August 2020 No. 776, eff. 9-1-20.

NR 666.021 NR 666.021 Standards applicable to generators and transporters of materials used in a manner that constitutes disposal. Generators and transporters of materials that are used in a manner that constitutes disposal are subject to the applicable requirements of chs. NR 662 and 663, and the notification requirement under s. NR 660.07.

NR 666.021 History History: CR 05-032: cr. Register July 2006 No. 607, eff. 8-1-06.

NR 666.022 NR 666.022 Standards applicable to storers of materials that are to be used in a manner that constitutes disposal who are not the ultimate users. Owners or operators of facilities that store recyclable materials that are to be used in a manner that constitutes disposal, but who are not the ultimate users of the materials, are regulated under all applicable provisions of subchs. A to L of ch. NR 664, all applicable provisions of subchs. A to L of ch. NR 665, all applicable provisions of subchs. A to J of ch. NR 667, all applicable provisions of NR 670 and the notification requirement under s. NR 660.07.

NR 666.022 History History: CR 05-032: cr. Register July 2006 No. 607, eff. 8-1-06; CR 19-082: am. Register August 2020 No. 776, eff. 9-1-20; correction made under s. 35.17, Stats., Register August 2020 No. 776.

NR 666.023 NR 666.023 Standards applicable to users of materials that are used in a manner that constitutes disposal.

NR 666.023(1) (1) Owners or operators of facilities that use recyclable materials in a manner that constitutes disposal are regulated under all applicable provisions of subchs. A to N of chs. NR 664 and 665, and chs. NR 668 and 670 and the notification requirement under s. NR 660.07. (These requirements do not apply to products which contain these recyclable materials under the provisions of s. NR 666.020 (2).)

NR 666.023(2) (2) The use of waste or used oil or other material, which is contaminated with dioxin or any other hazardous waste, for dust suppression or road treatment is prohibited.

NR 666.023 Note Note: See s. NR 679.82 regarding used oil as a dust suppressant.

NR 666.023 History History: CR 05-032: cr. Register July 2006 No. 607, eff. 8-1-06; CR 16-007: am. (2) Register July 2017 No. 739, eff. 8-1-17.

subch. F of ch. NR 666 Subchapter F — Recyclable Materials Used for Precious Metal Recovery

NR 666.070 NR 666.070 Applicability and requirements.

NR 666.070(1) (1) This subchapter applies to recyclable materials that are reclaimed to recover economically significant amounts of gold, silver, platinum, palladium, iridium, osmium, rhodium, ruthenium or any combination of these.

NR 666.070(2) (2) Persons who generate, transport or store recyclable materials that are regulated under this subchapter are subject to all of the following requirements:

NR 666.070(2)(a) (a) Notification requirements under s. NR 660.07.

NR 666.070(2)(b) (b) Subchapter B of ch. NR 662 for generators, ss. NR 663.20 and 663.21 for transporters and ss. NR 665.0071 and 665.0072 for persons who store.

NR 666.070 Note Note: Hazardous waste transportation licenses are not required for transporting only recyclable materials regulated under this subchapter.

NR 666.070(2)(c) (c) For precious metals exported to or imported from other countries for recovery, subch. H of ch. NR 662 and s. NR 665.0012.

NR 666.070(3) (3) Persons who store recycled materials that are regulated under this subchapter shall keep all of the following records to document that they are not accumulating these materials speculatively (as defined in s. NR 661.0001 (3)):

NR 666.070(3)(a) (a) Records showing the volume of these materials stored at the beginning of the calendar year.

NR 666.070(3)(b) (b) The amount of these materials generated or received during the calendar year.

NR 666.070(3)(c) (c) The amount of materials remaining at the end of the calendar year.

NR 666.070(4) (4) Recyclable materials that are regulated under this subchapter that are accumulated speculatively (as defined in s. NR 661.0001 (3)) are subject to all applicable provisions of chs. NR 662 to 665, 667 and 670.

NR 666.070 History History: CR 05-032: cr. Register July 2006 No. 607, eff. 8-1-06; CR 19-082: am. (2) (c), (3) (intro.), (4) Register August 2020 No. 776, eff. 9-1-20.

subch. G of ch. NR 666 Subchapter G — Spent Lead-Acid Batteries Being Reclaimed

NR 666.080 NR 666.080 Applicability and requirements.

NR 666.080(1) (1) A person that generates, collects, transports, stores or regenerates lead-acid batteries for reclamation purposes may be exempt from certain hazardous waste management requirements. Use the following table to determine which requirements apply. Alternatively, spent lead-acid batteries may be managed under ch. NR 673, the “Universal Waste” rule.

NR 666.080 Note Note: In addition to the requirements under this subchapter or ch. NR 673, s. 287.18, Stats., applies to persons who sell lead-acid batteries.

NR 666.080(2) (2) If I store spent lead-acid batteries before I reclaim them but not through regeneration, which requirements apply? The requirements of this subsection apply to you if you store spent lead-acid batteries before you reclaim them, but you don’t reclaim them through regeneration. The requirements are slightly different depending on your hazardous waste license status.

NR 666.080(2)(a) (a) If your facility has an interim license, you shall comply with all of the following:

NR 666.080(2)(a)1. 1. Notification requirements under s. NR 660.07.

NR 666.080(2)(a)2. 2. All applicable provisions in subch. A of ch. NR 665.

NR 666.080(2)(a)3. 3. All applicable provisions in subch. B of ch. NR 665 except s. NR 665.0013 (general waste analysis).

NR 666.080(2)(a)4. 4. All applicable provisions in subchs. C and D of ch. NR 665.

NR 666.080(2)(a)5. 5. All applicable provisions in subch. E of ch. NR 665 except ss. NR 665.0071 and 665.0072 (use of manifest system and manifest discrepancies).

NR 666.080(2)(a)6. 6. All applicable provisions in subchs. F to L of ch. NR 665.

NR 666.080(2)(a)7. 7. All applicable provisions in ch. NR 670.

NR 666.080(2)(a)8. 8. All applicable provisions under ch. NR 667.

NR 666.080(2)(b) (b) If your facility has an operating license, you shall comply with all of the following:

NR 666.080(2)(b)1. 1. Notification requirements under s. NR 660.07.

NR 666.080(2)(b)2. 2. All applicable provisions in subch. A of ch. NR 664.

NR 666.080(2)(b)3. 3. All applicable provisions in subch. B of ch. NR 664 except s. NR 664.0013 (general waste analysis).

NR 666.080(2)(b)4. 4. All applicable provisions in subchs. C and D of ch. NR 664.

NR 666.080(2)(b)5. 5. All applicable provisions in subch. E of ch. NR 664 except ss. NR 664.0071 and 664.0072 (use of manifest system and manifest discrepancies).

NR 666.080(2)(b)6. 6. All applicable provisions in subchs. F to L of ch. NR 664.

NR 666.080(2)(b)7. 7. All applicable provisions in ch. NR 670.

NR 666.080(2)(b)8. 8. All applicable provisions under ch. NR 667.

NR 666.080 History History: CR 05-032: cr. Register July 2006 No. 607, eff. 8-1-06; CR 16-007: am. (1) (a) to (e), cr. (2) Register July 2017 No. 739, eff. 8-1-17; CR 19-082: r. and recr. (1), cr. (2) (a) 8., (b) 8. Register August 2020 No. 776, eff. 9-1-20; correction in (1) (d), (f) to (j) made under s. 35.17, Stats., Register August 2020 No. 776.

subch. H of ch. NR 666 Subchapter H — Hazardous Waste Burned in Boilers and Industrial Furnaces

Subch. H of ch. NR 666 Note Note: This subchapter is similar to federal regulations contained in 40 CFR part 266 subpart H, revised as of July 1, 2003.

NR 666.100 NR 666.100 Applicability.

NR 666.100(1) (1) The regulations of this subchapter apply to hazardous waste burned or processed in a boiler or industrial furnace (as defined in s. NR 660.10) irrespective of the purpose of burning or processing, except as provided by subs. (2), (3), (4), (7) and (8). In this subchapter, the term “burn” means burning for energy recovery or destruction, or processing for materials recovery or as an ingredient. The emissions standards of ss. NR 666.104, 666.105, 666.106 and 666.107 apply to facilities operating under an interim license or under a license as specified in ss. NR 666.102 and 666.103.

NR 666.100(2) (2) 

NR 666.100(2)(a) (a) Except as provided by pars. (b), (c), and (d), the standards of this subchapter do not apply to a new hazardous waste boiler or industrial furnace unit that becomes subject to hazardous waste license requirements after October 12, 2005; or no longer apply when an affected source demonstrates compliance with the maximum achievable control technology (MACT) requirements of 40 CFR part 63, subpart EEE, by conducting a comprehensive performance test and submitting to the department a notification of compliance under 40 CFR 63.1207(j) and 63.1210(d) documenting compliance with 40 CFR part 63, subpart EEE. Nevertheless, even after this demonstration of compliance with the MACT standards, hazardous waste license conditions that were based on the standards of this chapter shall continue to be in effect until the conditions are removed from the license or the license is terminated or revoked, unless the license expressly provides otherwise.

NR 666.100(2)(b) (b) The following standards all continue to apply:

NR 666.100(2)(b)1. 1. If you elect to comply with s. NR 670.235 (1) (a) 1. to minimize emissions of toxic compounds from startup, shutdown and malfunction events, s. NR 666.102 (5) (a) requiring operations in accordance with the operating requirements specified in the license at all times that hazardous waste is in the unit, and s. NR 666.102 (5) (b) 3. requiring compliance with the emission standards and operating requirements during startup and shutdown if hazardous waste is in the combustion chamber, except for particular hazardous wastes. These provisions apply only during startup, shutdown and malfunction events.

NR 666.100(2)(b)2. 2. The closure requirements of ss. NR 666.102 (5) (k) and 666.103 (12).

NR 666.100(2)(b)3. 3. The standards for direct transfer of s. NR 666.111.

NR 666.100(2)(b)4. 4. The standards for regulation of residues of s. NR 666.112.

NR 666.100(2)(b)5. 5. The applicable requirements of subchs. A to H, BB and CC of ch. NR 664 and subchs. A to H, BB and CC of ch. NR 665.

NR 666.100(2)(c) (c) If an owner or operator of a boiler or hydrochloric acid production furnace that is an area source under 40 CFR 63.2 and the owner or operator elects not to comply with the emission standards under 40 CFR 63.1216, 63.1217, and 63.1218 for particulate matter, semi-volatile and low volatile metals and total chlorine, the owner or operator remains subject to:

NR 666.100(2)(c)1. 1. Section NR 666.105—Standards to control particulate matter.

NR 666.100(2)(c)2. 2. Section NR 666.106—Standards to control metals emissions, except for mercury.

NR 666.100(2)(c)3. 3. Section NR 666.107—Standards to control hydrogen chloride and chlorine gas.

NR 666.100(2)(d) (d) The particulate matter standard of s. NR 666.105 remains in effect for boilers that elect to comply with the alternative to the particulate matter standard under 40 CFR 63.1216(e) and 63.1217(e).

NR 666.100(3) (3) The following hazardous wastes and facilities are not subject to regulation under this subchapter:

NR 666.100(3)(a) (a) Used oil burned for energy recovery that is also a hazardous waste solely because it exhibits a characteristic of hazardous waste identified in subch. C of ch. NR 661. Such used oil is subject to regulation under ch. NR 679.

NR 666.100(3)(b) (b) Gas recovered from hazardous or solid waste landfills when such gas is burned for energy recovery.

NR 666.100(3)(c) (c) Hazardous wastes that are exempt from regulation under ss. NR 661.0004 and 661.0006 (1) (c) 3. and 4., and hazardous wastes that are subject to the special requirements for very small quantity generators under ss. NR 662.013 and 662.014.

NR 666.100(3)(d) (d) Coke ovens, if the only hazardous waste burned is EPA hazardous waste number K087, decanter tank tar sludge from coking operations.

NR 666.100(4) (4) Owners and operators of smelting, melting and refining furnaces (including pyrometallurgical devices such as cupolas, sintering machines, roasters and foundry furnaces, but not including cement kilns, aggregate kilns or halogen acid furnaces burning hazardous waste) that process hazardous waste solely for metal recovery are conditionally exempt from regulation under this subchapter, except for ss. NR 666.101 and 666.112.

NR 666.100(4)(a) (a) To be exempt from ss. NR 666.102 to 666.111, an owner or operator of a metal recovery furnace or mercury recovery furnace shall comply with all of the following requirements, except that an owner or operator of a lead or a nickel-chromium recovery furnace, or a metal recovery furnace that burns baghouse bags used to capture metallic dusts emitted by steel manufacturing, shall comply with par. (c), and owners or operators of lead recovery furnaces that are subject to regulation under the Secondary Lead Smelting national emission standards for hazardous air pollutants (NESHAP) shall comply with sub. (8).

NR 666.100(4)(a)1. 1. Provide a one-time written notice to the department indicating all of the following:

NR 666.100(4)(a)1.a. a. The owner or operator claims exemption under this subsection.

NR 666.100(4)(a)1.b. b. The hazardous waste is burned solely for metal recovery consistent with par. (b).

NR 666.100(4)(a)1.c. c. The hazardous waste contains recoverable levels of metals.

NR 666.100(4)(a)1.d. d. The owner or operator will comply with the sampling and analysis and recordkeeping requirements of this subsection.

NR 666.100(4)(a)2. 2. Sample and analyze the hazardous waste and other feedstocks as necessary to comply with this subsection by using appropriate methods.