NR 407.10(3)(d)(d) The department shall grant coverage under the general operation permit if the owner or operator of the source applies for coverage and meets the eligibility requirements of the general operation permit, unless the source is ineligible for coverage under sub. (2). NR 407.10(4)(4) Construction and modification under a general operation permit. NR 407.10(4)(a)(a) Notwithstanding the provisions in s. NR 406.04 (1) and (2), no construction permit is required prior to commencing construction, reconstruction, replacement, relocation or modification of a stationary source if the source is covered under a general operation permit and all of the following criteria are met: NR 407.10(4)(a)1.1. The construction, reconstruction, replacement, relocation or modification will not result in the source violating any term or condition of the general operation permit. NR 407.10(4)(a)2.2. The construction, reconstruction, replacement, relocation or modification does not require a permit under ch. NR 405 or 408. NR 407.10 NoteNote: Some general operation permits issued prior to September 1, 2005 may have required a construction permit, even if the change at the source would not violate any term or condition of the permit. Those sources are now exempt from the requirement to obtain a construction permit if the change at the source will not violate any term or condition of the general operation permit.
NR 407.10(4)(b)(b) No later than 30 calendar days from commencing construction, reconstruction, replacement, relocation or modification, the owner or operator shall notify the department of the action and provide information explaining how the source is meeting the criteria for an exemption under par. (a). NR 407.10(4)(c)(c) If a construction permit is required, the owner or operator shall obtain a construction permit under ch. NR 405, 406 or 408, as applicable. The owner or operator may not commence construction, reconstruction, replacement, relocation or modification prior to receiving the construction permit. The owner or operator shall also apply for an individual operation permit, a revision of its operation permit or a registration operation permit under this chapter. NR 407.10 NoteNote: The construction permit may be an individual, general or registration construction permit.
NR 407.10(5)(a)(a) An owner or operator of a stationary source that is covered under a general operation permit may submit a request to the department to withdraw the source from coverage under the general operation permit and allow the source to be covered under a registration operation permit or a general operation permit for another source category or be issued an individual operation permit. The owner or operator shall submit a written request for the withdrawal of the general operation permit and a complete application for a different operation permit. NR 407.10(5)(b)(b) An owner or operator of a stationary source that has an individual operation permit may submit a request to the department to revise or revoke the individual operation permit pursuant to s. NR 407.12, 407.13, or 407.15 (4) and allow the source be covered under a general operation permit. A complete application for a general operation permit submitted under this section shall be considered a request for revocation of the existing individual operation permit. NR 407.10(5)(c)(c) An owner or operator of a stationary source that is covered under a registration operation permit may submit a request to the department to withdraw the source from coverage under the registration operation permit and allow the source to be covered under a general operation permit. A complete application for a general operation permit submitted under this section shall be considered a request for withdrawal of coverage under the registration permit. NR 407.10(5)(e)(e) The owner or operator of a facility submitting an application for a different permit under this subsection shall comply with the existing permit until the department has issued or granted coverage under the different permit. NR 407.10(6)(6) Additional provisions related to general operation permits. Notwithstanding the permit shield provision in section 504(f) of the Act (42 USC 7661c(f)) and in s. 285.62 (10) (b), Stats., an owner or operator of a source which is covered under a general operation permit may be prosecuted for operation without an individual operation permit if the source is later determined not to qualify for the conditions and terms of the general operation permit. NR 407.10 HistoryHistory: Cr. Register, December, 1993, No. 456, eff. 1-1-94; am. (2) (intro.), r. (2) (e), Register, December, 1996, No. 492, eff. 1-1-97; cr. (9), Register, December, 1997, No. 504, eff. 1-1-98; am. (6) (intro.) and cr. (6) (a) (intro.), Register, October, 1999, No. 526, eff. 11-1-99; CR 04-107: r. and recr. Register August 2005 No. 596, eff. 9-1-05; CR 07-040: am. (4) (a) 2., cr. (4) (a) 2. (note) Register April 2008 No. 628, eff. 5-1-08; CR 15-005: am. (5) (b), (c), r. (5) (d) Register November 2015 No. 719, eff. 12-1-15. NR 407.105NR 407.105 Registration operation permits. NR 407.105(1)(a)(a) The department may issue a registration permit for the operation of an entire facility that has or will have low actual or potential emissions in accordance with s. 285.60 (2g), Stats. NR 407.105 NoteNote: No construction permit is required prior to commencing construction, reconstruction, replacement, relocation or modification of a stationary source if the source is covered under a registration operation permit and the project meets the criteria in s. NR 407.105 (5) (a). NR 407.105(1)(b)(b) When proposing to issue a registration operation permit, the department shall prepare an air quality analysis and a preliminary determination on the approvability of the proposed registration operation permit. The department shall use the applicable procedures of s. 285.62, Stats., to issue the registration operation permit. The department may issue the registration operation permit if the applicable criteria in ss. 285.63 and 285.64, Stats., are met. The procedural requirements of s. 285.62 (2) to (7), Stats., do not apply to the determination of whether an individual facility is covered by a registration operation permit. NR 407.105 NoteNote: The statutes cited above require that when issuing the registration operation permit, the department distribute a notice of the availability of the proposed operation permit and of the department’s analysis and preliminary determination, a notice of the opportunity for public comment and a notice of the opportunity to request a public hearing. There will be a 30-day public comment period and the department may hold a public hearing within 60 days after the deadline for requesting one.
NR 407.105(1)(c)(c) The registration operation permit shall contain applicability criteria, emission caps and limitations, monitoring and recordkeeping requirements, reporting requirements, compliance demonstration methods and general conditions appropriate for determining compliance with the terms and conditions of the registration operation permit. The permit terms and conditions shall be those required to comply with the Act and those required to assure compliance with applicable provisions in ch. 285, Stats., and chs. NR 400 to 499. Notwithstanding the requirements in s. NR 424.03 (2) (c) to determine the latest available control techniques and operating practices demonstrating best current technology (LACT) for a specific process line, the department may include conditions in the registration operation permit that represent LACT, if the requirements of s. NR 424.03 (2) (a) or (b) are determined to be technologically infeasible. NR 407.105 NoteNote: If an area is designated nonattainment for particulate matter, PM10, sulfur dioxide, nitrogen oxides, carbon monoxide or lead, the department may revise the registration operation permit, or issue a different one, to include nonattainment area specific applicability criteria.
NR 407.105(2)(2) Criteria for issuance of a registration operation permit. NR 407.105(2)(a)(a) A registration operation permit shall be issued for facilities that meet all of the criteria: NR 407.105(2)(a)1.1. The calendar year sum of actual emissions of each air contaminant from the facility may not exceed 25% of any major source threshold in s. NR 407.02 (4), except that for lead, emissions may not exceed 0.5 tons per calendar year. NR 407.105(2)(a)2.2. The stack-vented emissions are exhausted from unobstructed discharge points that are within 10 degrees of vertical. This criterion does not apply to stacks serving any of the emission units listed in s. NR 407.05 (4) (c) 9. For the purposes of this paragraph, horizontal discharge vents that only discharge general building ventilation are not considered stacks. NR 407.105 NoteNote: Valves designed to open and close at the point of discharge are considered to be unobstructed if they are open at the time of emission.
NR 407.105(2)(a)3.3. The stack is taller than any building that influences the dispersion of emissions from the stack. A building is considered to influence the dispersion of emissions from any stack that exists within a circle around the building, the radius of which is 5 times the height of the building. This criterion does not apply to stacks serving any of the emission units listed in s. NR 407.05 (4) (c) 9. For the purposes of this paragraph, horizontal discharge vents that only discharge general building ventilation are not considered stacks. NR 407.105(2)(a)4.4. An owner or operator of a facility whose stacks do not meet the criteria in subds. 2. and 3. may demonstrate through air dispersion modeling that the facility’s emissions do not and will not cause or exacerbate a violation of any ambient air quality standard or ambient air increment. If an air dispersion model is not available for one or more pollutants, the demonstration for that pollutant shall rely on the department’s air quality analysis conducted under sub. (1) (b). NR 407.105(2)(b)(b) Notwithstanding par. (a), the department may issue registration operation permits for coverage of other types of facilities that the department determines have or will have low actual or potential emissions, in response to a petition submitted under s. NR 407.107. NR 407.105(3)(3) Sources ineligible for coverage under a registration operation permit. Notwithstanding the existence of a registration operation permit, an individual facility may not be covered under a registration operation permit if any of the following criteria apply: NR 407.105(3)(b)(b) One or more emissions units at the facility would be subject to an emission limitation or emission standard under section 111 of the Act (42 USC 7411) or under section 112 of the Act (42 USC 7412), other than those contained in the registration operation permit or determined by the department to not preclude eligibility for the registration operation permit. NR 407.105(3)(c)(c) The facility’s emissions cause or exacerbate, or may cause or exacerbate, a violation of any ambient air quality standard or ambient air increment, as determined by the department through an air quality assessment conducted in accordance with s. NR 407.15 (8). NR 407.105(4)(4) Procedure for determining coverage under a registration operation permit for an individual facility. NR 407.105(4)(a)(a) An owner or operator of a facility who applies for coverage under a registration operation permit shall submit an application using department approved forms. NR 407.105 NoteNote: Contact the regional offices or service centers of the department or the Permits and Stationary Source Modeling Section of the Bureau of Air Management, 608-266-7718, for information on how to obtain and submit the department approved registration permit application forms.
NR 407.105(4)(b)(b) An owner or operator of a facility who requests or requires emission limits, terms or conditions that require case-by-case review and approval by the department, or emission limits, terms or conditions other than, or in addition to, those contained in the registration operation permit, shall apply for a different type of permit. NR 407.105(4)(c)(c) Within 15 days after the receipt of an application for coverage, the department shall provide one of the following to an applicant for a registration operation permit: NR 407.105(4)(c)1.1. Written notice of the department’s determination that the facility is covered under a registration operation permit. NR 407.105(4)(c)2.2. A written description of any information that is missing from the application for coverage under a registration operation permit. NR 407.105(4)(c)3.3. Written notice of the department’s determination that the facility does not qualify for coverage under a registration operation permit, specifically describing the reasons for that determination. NR 407.105(4)(d)(d) The department shall grant coverage under the registration operation permit if the owner or operator of the facility applies for coverage and meets the eligibility requirements in the registration operation permit, unless the facility is ineligible for coverage under sub. (3). NR 407.105(4)(e)(e) For the purpose of determining whether a source is eligible for coverage under a registration operation permit, the source’s emissions shall be calculated using the terms and conditions listed in the registration operation permit. NR 407.105 NoteNote: The permit terms and conditions may include capture and control efficiencies. The Air Emissions Management System (AEMS) requires the owner or operator of a source to calculate actual annual emissions for reporting to the inventory using the terms and conditions in a permit.
NR 407.105(5)(5) Construction or modification under a registration operation permit. NR 407.105(5)(a)(a) No construction permit is required prior to commencing construction, reconstruction, replacement, relocation or modification of a stationary source if the facility is covered under a registration operation permit and the construction, reconstruction, replacement, relocation or modification will not result in the facility violating any term or condition of the registration operation permit. NR 407.105(5)(b)(b) If a construction permit is required, the owner or operator shall obtain a construction permit under ch. NR 405, 406, or 408, as applicable. The owner or operator may not commence construction prior to receiving the construction permit. The owner or operator shall also apply for an individual operation permit, a revision of its individual operation permit or a general operation permit under this chapter. NR 407.105 NoteNote: The construction permit may be an individual, general or registration construction permit.
NR 407.105(6)(a)(a) An owner or operator of a facility that is covered under a registration operation permit may submit a request to the department to withdraw the source from coverage under the registration operation permit and allow the facility to be covered under a general operation permit or be issued an individual operation permit. The owner or operator shall submit a written request for the withdrawal of the registration operation permit and a complete application for an individual or general operation permit under s. NR 407.05 or 407.10. NR 407.105(6)(b)(b) An owner or operator of a facility that has an individual operation permit may submit a request to the department to revoke the individual operation permit pursuant to s. NR 407.15 and allow the facility to be covered under a registration operation permit. A complete application for a registration operation permit submitted under this section shall be considered a request for revocation of the existing individual operation permit. NR 407.105(6)(c)(c) An owner or operator of a facility that is covered under a general operation permit may submit a request to the department to withdraw coverage under the general operation permit and allow the facility to be covered under a registration operation permit. A complete application for a registration operation permit submitted under this section shall be considered a request for withdrawal of coverage under the general permit. NR 407.105(6)(d)(d) The owner or operator shall submit a request for revocation or withdrawal of an operation permit under this subsection on department approved forms. NR 407.105 NoteNote: Contact the regional offices or service centers of the department or the Permits and Stationary Source Modeling Section of the Bureau of Air Management, 608-266-7718, for information on how to obtain and submit the department approved forms.
NR 407.105(6)(e)(e) The owner or operator of a facility submitting an application for a different permit under this subsection shall comply with the existing permit until the department has issued or granted coverage under the different permit. NR 407.105(7)(7) Additional provisions related to registration operation permits. NR 407.105(7)(a)(a) An owner or operator of a facility operating in compliance with a registration operation permit shall be deemed to be in compliance with the applicable requirements in chs. NR 400 to 499 if the owner or operator conducts a reasonable search and evaluation to identify applicable requirements and to determine whether the facility is meeting the applicable requirements, is operating in compliance with these applicable requirements and complies with par. (b). A reasonable search and evaluation includes a search and evaluation of chs. NR 400 to 499, and shall include a reasonable effort to review other readily accessible information relevant to the facility’s operations, such as data bases, workshops and materials available through trade associations, vendors, the department’s small business clean air assistance program, the U.S. environmental protection agency and other recognized sources of information on air regulations. The owner or operator shall document, in writing, the results of the search and evaluation and shall keep the documents at the facility for inspection upon request for as long as the facility is covered under the registration operation permit. NR 407.105(7)(b)(b) The owner or operator will not be deemed to be out of compliance with the applicable requirements in chs. NR 400 to 499 if an applicable requirement that was previously not identified through the search and evaluation described in par. (a) is later identified, if the owner or operator does all of the following: NR 407.105(7)(b)1.1. Submits written notification to the department within 21 days of identifying the applicable requirement. NR 407.105(7)(b)2.2. Certifies that the facility is in compliance with the applicable requirement no later than 90 days after notifying the department. If requested, the department may extend the deadline for achieving compliance. NR 407.105(7)(b)3.3. Submits documentation to demonstrate that the search and evaluation that was conducted prior to identifying the applicable requirement was reasonable. NR 407.105(7)(c)(c) Notwithstanding par. (b), the department retains the authority to order the owner or operator to achieve compliance with the applicable requirements within a specific time period shorter than the 90 calendar days whenever compliance in the shorter period of time is feasible and necessary to protect public health and the environment. NR 407.105 NoteNote: Contact the Compliance and Enforcement Section of the Bureau of Air Management, 608-266-7718, for information on submitting the notification.
NR 407.105 HistoryHistory: CR 04-107: cr. Register August 2005 No. 596, eff. 9-1-05; correction in (7) (a) made under s. 13.92 (4) (b) 6., Stats., Register January 2012 No. 673; correction in (7) (a) made under s. 13.92 (4) (b) 6., Stats., Register February 2012 No. 674; correction in (3) (a) made under s. 13.92 (4) (b) 7., Stats., Register February 2014 No. 698; CR 15-005: r. (4) (f), am. (6) (b), (c) Register November 2015 No. 719, eff. 12-1-15; CR 19-015: am. (3) (b) Register September 2020 No. 777, eff. 10-1-20. NR 407.107NR 407.107 Petitions for issuance of general operation permits and registration operation permits. NR 407.107(1)(1) A person may petition the department to make a determination that a category of stationary source meets the criteria for a general operation permit under s. 285.60 (3), Stats., and s. NR 407.10 (1). A person may petition the department to make a determination that a stationary source meets the criteria for a registration operation permit under s. 285.60 (2g), Stats., and s. NR 407.105 (1) and (2) (b). The department may consider the number of sources that would be eligible for the permit, the complexity of air regulations applicable to the sources, the likelihood that sources would need source-specific emission limitations and other factors in determining its priority for developing a general or registration operation permit. Within 30 days after receipt of the petition, the department shall provide a written response to the petitioner granting or denying the petition. If the department grants the petition, the department shall issue the general operation permit or the registration operation permit as soon as practicable, but no later than 365 days after receipt of the petition. NR 407.107(2)(2) The person shall submit the petition using department approved petition forms. NR 407.107 NoteNote: Contact the regional offices or service centers of the department or the Permits and Stationary Source Modeling Section of the Bureau of Air Management, 608-266-7718, for information on how to obtain and submit the department approved forms.
NR 407.107 HistoryHistory: CR 04-107: cr. Register August 2005 No. 596, eff. 9-1-05. NR 407.11NR 407.11 Administrative permit revisions. NR 407.11(1)(1) Eligibility. Upon request of a permittee, the department may revise an operation permit administratively using the procedures in this section if the revision requested is one of the following: NR 407.11(1)(b)(b) A change in the name, address or telephone number of any person identified in the permit, or a similar administrative change at the stationary source, unrelated to emissions. NR 407.11(1)(c)(c) More frequent monitoring, recordkeeping or reporting by the permittee. NR 407.11(1)(d)(d) A change in ownership or operational control of a stationary source if the department determines that no other change in the permit is necessary, provided that a written agreement containing a specific date for transfer of permit responsibility, coverage and liability between the current and new permittee has been submitted to the department. NR 407.11(2)(2) Acid rain. Administrative permit revisions to the acid rain provisions of the permit shall be governed by s. NR 409.12. NR 407.11(3)(3) Procedures. The department shall use the following procedures in processing administrative permit revisions: NR 407.11(3)(a)(a) Any person holding an operation permit who seeks an administrative permit revision shall file a written request with the department. The request shall identify the permit to be administratively revised, outline the specific item for which a revision is sought, and set forth the reasons why a permit revision is sought. The request shall be signed by a responsible official and shall be provided to the bureau of air management, either by personal delivery to the office, located at 101 South Webster Street, Madison, Wisconsin, or by mailing to the following address: PO Box 7921, Madison WI 53707. NR 407.11(3)(b)(b) The department shall act on a request for an administrative permit revision within 60 days of receipt of a complete request under this section. The department may administratively revise the operation permit, without providing notice or opportunity for comment or hearing to the public, affected states or EPA, provided that the department determines the revision is one allowed under this section. NR 407.11(4)(4) Schedule. The permittee may implement the change addressed in the request for an administrative permit revision immediately upon submittal of the request. If the department determines that the proposed change may not be made pursuant to an administrative permit revision, and the permittee has already made the change at the facility, the permittee shall be liable for violation of the permit condition it is requesting to be revised. NR 407.11 HistoryHistory: Cr. Register, December, 1993, No. 456, eff. 1-1-94; am. (2), Register, April, 1995, No. 472, eff. 5-1-95; CR 04-106: cr. (1) (e) Register November 2005 No. 599, eff. 12-1-05; CR 19-015: r. (1) (e), (3) (c) Register September 2020 No. 777, eff. 10-1-20. NR 407.12(1)(1) Eligibility. Any person holding an operation permit may submit a request to the department to revise the operation permit, to reflect a proposed change at the facility, using the minor permit revision procedures described in this section, provided the proposed change meets all of the following criteria: NR 407.12(1)(b)(b) Does not involve significant changes to existing monitoring, reporting or recordkeeping requirements in the permit. NR 407.12(1)(c)(c) Does not require or change a source-specific determination of an emission limitation or other standard, a source-specific limitation based on ambient air impacts or a visibility or ambient air increment analysis.
