Chapter NR 273

NR 273.072 NR 273.072 Effluent limitations representing the degree of effluent reduction attainable by the application of the best practicable control technology currently available. Except as provided in 40 CFR 125.30 to 125.32, any existing point source subject to this subchapter shall achieve the following effluent limitations representing the degree of effluent reduction attainable by application of BPT:

NR 273.072 History History: Cr. Register, September, 1990, No. 417, eff. 10-1-90.

NR 273.073 NR 273.073 Effluent limitations representing the degree of effluent reduction attainable by the application of the best available technology economically achievable. Except as provided in 40 CFR 125.30 to 125.32, any existing point source subject to this subchapter shall achieve the following effluent limitations representing the degree of effluent reduction attainable by application of BAT:

NR 273.073 History History: Cr. Register, September, 1990, No. 417, eff. 10-1-90.

NR 273.074 NR 273.074 New source performance standards. Any new source subject to this subchapter shall achieve the following standards:

NR 273.074 History History: Cr. Register, September, 1990, No. 417, eff. 10-1-90.

NR 273.076 NR 273.076 Pretreatment standards for new sources. Except as provided in s. NR 211.13, any new source subject to this subchapter which introduces pollutants into a POTW shall comply with ch. NR 211 and achieve the limitations set forth in s. NR 273.073.

NR 273.076 History History: Cr. Register, September, 1990, No. 417, eff. 10-1-90.

subch. VIII of ch. NR 273 Subchapter VIII — Zinc

NR 273.08 NR 273.08 Applicability; description of the zinc subcategory. This subchapter applies to the discharge of pollutants to waters of the state and the introduction of pollutants into POTWs from zinc forming.

NR 273.08 History History: Cr. Register, September, 1990, No. 417, eff. 10-1-90.

NR 273.081 NR 273.081 Discharge prohibitions. Any facility subject to this subchapter may not discharge process wastewater pollutants from the following sources:

NR 273.081(1) (1) Rolling spent neat oils;

NR 273.081(2) (2) Stationary casting contact cooling water; and

NR 273.081(3) (3) Degreasing spent solvents.

NR 273.081 History History: Cr. Register, September, 1990, No. 417, eff. 10-1-90.

NR 273.082 NR 273.082 Effluent limitations representing the degree of effluent reduction attainable by the application of the best practicable control technology currently available. Except as provided in 40 CFR 125.30 to 125.32, any existing point source subject to this subchapter shall achieve the following effluent limitations representing the degree of effluent reduction attainable by application of BPT:

NR 273.082 History History: Cr. Register, September, 1990, No. 417, eff. 10-1-90.

NR 273.083 NR 273.083 Effluent limitations representing the degree of effluent reduction attainable by the application of the best available technology economically achievable. Except as provided in 40 CFR 125.30 to 125.32, any existing point source subject to this subchapter shall achieve the following effluent limitations representing the degree of effluent reduction attainable by application of BAT:

NR 273.083 History History: Cr. Register, September, 1990, No. 417, eff. 10-1-90.

NR 273.084 NR 273.084 New source performance standards. Any new source subject to this subchapter shall achieve the following standards:

NR 273.084 History History: Cr. Register, September, 1990, No. 417, eff. 10-1-90.

NR 273.086 NR 273.086 Pretreatment standards for new sources. Except as provided in s. NR 211.13, any new source subject to this subchapter which introduces pollutants into a POTW shall comply with ch. NR 211 and achieve the limitations set forth in s. NR 273.083.

NR 273.086 History History: Cr. Register, September, 1990, No. 417, eff. 10-1-90.

subch. IX of ch. NR 273 Subchapter IX — Zirconium-Hafnium

NR 273.09 NR 273.09 Applicability; description of the zirconium-hafnium subcategory. This subchapter applies to the discharge of pollutants to waters of the state and the introduction of pollutants into POTWs from zirconium-hafnium forming.

NR 273.09 History History: Cr. Register, September, 1990, No. 417, eff. 10-1-90.

NR 273.091 NR 273.091 Discharge prohibitions.

NR 273.091(1) (1) Any facility subject to this subchapter may not discharge process wastewater pollutants from the following sources:

NR 273.091(1)(a) (a) Rolling spent neat oils;

NR 273.091(1)(b) (b) Drawing spent lubricants;

NR 273.091(1)(c) (c) Extrusion spent emulsions;

NR 273.091(1)(d) (d) Swaging spent neat oils;

NR 273.091(1)(e) (e) Wet air pollution control scrubber blowdown;

NR 273.091(1)(f) (f) Degreasing spent solvents;

NR 273.091(1)(g) (g) Degreasing rinse; and

NR 273.091(1)(h) (h) Swaging or grinding spent neat oils.

NR 273.091(2) (2) Tube reducing spent lubricants.

NR 273.091(2)(a) (a) Tube reducing spent lubricant process wastewater pollutants may not be discharged, except as provided in par. (b).

NR 273.091(2)(b) (b) Tube reducing spent lubricant process wastewater pollutants may be discharged, with no allowance for any pollutants discharged, if the facility owner or operator demonstrates according to pars. (c), (d), (e), and (f) that the concentrations of nitrosamine compounds in the discharged wastewater do not exceed the following levels:

NR 273.091(2)(c) (c) For the demonstration required by par. (b), the facility owner or operator shall use the analytical methods approved by ch. NR 219, Table C.

NR 273.091(2)(d) (d) The demonstration required by par. (b) shall be made once per month until the demonstration has been made for all 3 nitrosamine compounds for 6 consecutive months. After this time, the demonstration may be made once per quarter. If a sample is found to contain any of the 3 nitrosamine compounds at concentrations greater than those specified in par. (b), the actions set forth in par. (e) shall be taken and the demonstration required by par. (b) shall be made once per month until it has been made for all 3 nitrosamine compounds for 6 consecutive months.

NR 273.091(2)(e) (e) If sampling results show that any of the 3 nitrosamine compounds is present in the process wastewater at concentrations greater than those set forth in par. (b), the facility owner or operator shall ensure that starting within 30 days of receiving written notification of the sampling results no tube reducing spent lubricant wastewater is discharged until one of the following conditions is met:

NR 273.091(2)(e)1. 1. The owner or operator performs a subsequent analysis which demonstrates that the concentrations of 3 regulated nitrosamine compounds do not exceed the levels set forth in par. (b); or

NR 273.091(2)(e)2. 2. The owner or operator substitutes a new tube reducing lubricant and thereafter complies with the requirements of par. (d); or

NR 273.091(2)(e)3. 3. Determines the source of the pollutants whose concentration exceeded the level set forth in par. (b) and demonstrates to the satisfaction of the permit issuing authority that the source has been eliminated.

NR 273.091(2)(f) (f) The concentration limits specified in par. (b) apply at the point of discharge from the tube reducing process. However, sampling after the tube reducing wastewater has been commingled with other wastewaters is permitted if 2 conditions are met:

NR 273.091(2)(f)1. 1. Any dilution caused by the other wastewaters is accounted for when determining the appropriate allowable discharge concentration; and

NR 273.091(2)(f)2. 2. An analytical method of sufficient sensitivity is used to measure the levels of each of the 3 nitrosamine compounds in the wastewater being sampled.

NR 273.091 History History: Cr. Register, September, 1990, No. 417, eff. 10-1-90.

NR 273.092 NR 273.092 Effluent limitations representing the degree of effluent reduction attainable by the application of the best practicable control technology currently available. Except as provided in 40 CFR 125.30 to 125.32, any existing point source subject to this subchapter shall achieve the following effluent limitations representing the degree of effluent reduction attainable by application of BPT:

NR 273.092 History History: Cr. Register, September, 1990, No. 417, eff. 10-1-90.

NR 273.093 NR 273.093 Effluent limitations representing the degree of effluent reduction attainable by the application of the best available technology economically achievable. Except as provided in 40 CFR 125.30 to 125.32, any existing point source subject to this subchapter shall achieve the following effluent limitations representing the degree of effluent reduction attainable by application of BAT:

NR 273.093 History History: Cr. Register, September, 1990, No. 417, eff. 10-1-90.

NR 273.094 NR 273.094 New source performance standards. Any new source subject to this subchapter shall achieve the following standards:

NR 273.094 History History: Cr. Register, September, 1990, No. 417, eff. 10-1-90.

NR 273.095 NR 273.095 Pretreatment standards for existing sources. Except as provided in ss. NR 211.13 and 211.14, any existing source subject to this subchapter which introduces pollutants into a POTW shall comply with ch. NR 211 and achieve the limitations set forth in s. NR 273.093.

NR 273.095 History History: Cr. Register, September, 1990, No. 417, eff. 10-1-90.

NR 273.096 NR 273.096 Pretreatment standards for new sources. Except as provided in s. NR 211.13, any new source subject to this subchapter which introduces pollutants into a POTW shall comply with ch. NR 211 and achieve the limitations set forth in s. NR 273.093.

NR 273.096 History History: Cr. Register, September, 1990, No. 417, eff. 10-1-90.

subch. X of ch. NR 273 Subchapter X — Metal Powders

NR 273.10 NR 273.10 Applicability; description of the metal powders subcategory. This subchapter applies to the discharge of pollutants to waters of the state and the introduction of pollutants into POTWs from metal powders forming.

NR 273.10 History History: Cr. Register, September, 1990, No. 417, eff. 10-1-90.

NR 273.101 NR 273.101 Discharge prohibitions. Any facility subject to this subchapter may not discharge process wastewater pollutants from the following sources:

NR 273.101(1) (1) Oil-resin impregnation wastewater;

NR 273.101(2) (2) Sawing or grinding spent neat oils; and

NR 273.101(3) (3) Degreasing spent solvents.

NR 273.101 History History: Cr. Register, September, 1990, No. 417, eff. 10-1-90.

NR 273.102 NR 273.102 Effluent limitations representing the degree of effluent reduction attainable by the application of the best practicable control technology currently available. Except as provided in 40 CFR 125.30 to 125.32, any existing point source subject to this subchapter shall achieve the following effluent limitations representing the degree of effluent reduction attainable by application of BPT:

NR 273.102 History History: Cr. Register, September, 1990, No. 417, eff. 10-1-90.

NR 273.103 NR 273.103 Effluent limitations representing the degree of effluent reduction attainable by the application of the best available technology economically achievable. Except as provided in 40 CFR 125.30 to 125.32, any existing point source subject to this subchapter shall achieve the following effluent limitations representing the degree of effluent reduction attainable by application of BAT:

NR 273.103 History History: Cr. Register, September, 1990, No. 417, eff. 10-1-90.

NR 273.104 NR 273.104 New source performance standards. Any new source subject to this subchapter shall achieve the following standards:

NR 273.104 History History: Cr. Register, September, 1990, No. 417, eff. 10-1-90.

NR 273.105 NR 273.105 Pretreatment standards for existing sources. Except as provided in ss. NR 211.13 and 211.14, any existing source subject to this subchapter which introduces pollutants into a POTW shall comply with ch. NR 211 and achieve the limitations set forth in s. NR 273.103.

NR 273.105 History History: Cr. Register, September, 1990, No. 417, eff. 10-1-90.

NR 273.106 NR 273.106 Pretreatment standards for new sources. Except as provided in s. NR 211.13, any new source subject to this subchapter which introduces pollutants into a POTW shall comply with ch. NR 211 and achieve the limitations set forth in s. NR 273.103.

NR 273.106 History History: Cr. Register, September, 1990, No. 417, eff. 10-1-90.

NR 273.106 Note Note: The Wisconsin administrative code corresponds to the code of federal regulations as cross referenced in the following table: