NR 407.03(1)(sm)3.
3. Pilot testing of a negative pressure venting system provided the testing is limited to a total withdrawal of not more than 150,000 standard cubic feet (scf) of air.
NR 407.03 Note
Note: The total withdrawal may be determined by the equation: Total withdrawal (scf) = hours of operation of pilot test (hr) ×
average flow rate in cubic feet per minute at standard conditions (scfm) × 60 min/hr. An example is: 10 hours of operation ×
250 scfm × 60 min/hr = 150,000 scf. When testing at multiple flow rates, determine the withdrawal for each flow rate and sum the withdrawals for a total withdrawal.
NR 407.03(1)(sm)5.
5. Installation and use of devices which remove organic compounds from a private or municipal potable water supply.
NR 407.03(1)(sm)6.
6. Installation and use of crop irrigation systems or dewatering wells to remediate contaminated water.
NR 407.03(1)(sm)7.
7. Installation and use of air strippers for treatment of contaminated water, provided the remediation is completed within 18 months or the potential to emit organic compounds from the remediation site is at a rate of not more than 5.7 pounds per hour, considering emission control devices.
NR 407.03(1)(sm)8.
8. Installation and use of any devices or techniques not listed in this paragraph which are used to remediate soil or water contaminated with organic compounds, if the device or technique is not portable and is not a thermal evaporation unit, and the remediation is completed within 18 months.
NR 407.03(1)(sm)9.
9. Installation and use of any technique or device to remediate soil or water contaminated with organic compounds as part of actions taken by EPA under the authority of the comprehensive environmental response compensation and liability act of 1980 (
42 USC 9601 to
9675), by the department under the authority of s.
292.11 or
292.31, Stats., or by a responsible party in compliance with the requirements of an administrative order, consent decree or contract issued pursuant to the comprehensive environmental response compensation and liability act of 1980 or s.
292.11 or
292.31, Stats.
NR 407.03(1)(sq)
(sq) Renovation or demolition operations involving regulated asbestos-containing material.
NR 407.03(1)(t)
(t) A combination of emission units which consists of not more than one each of the following specific categories of sources unless the combination of units is a major source:
NR 407.03(1)(t)3.
3. Storage tanks of organic compounds with a combined total tankage capacity of not more than 40,000 gallons if not more than 10,000 gallons of the storage tanks' capacity is used for storage of volatile organic compounds.
NR 407.03(1)(u)
(u) Restricted use reciprocating internal combustion engines which are fueled by gaseous fuels, gasoline, or a clean fuel as defined in s.
NR 406.02 (1) and which have a combined total electrical output of less than 3,000 kilowatts, or the equivalent in brake horsepower. An owner or operator claiming exemption under this paragraph shall maintain records of all of the following:
NR 407.03(1)(u)1.
1. The electrical output in kilowatts, or the equivalent in brake horsepower, of each engine.
NR 407.03(1)(v)
(v) Any quarry, mine or other facility where nonmetallic minerals are extracted that is not a ledge rock quarry or industrial sand mine.
NR 407.03(1)(w)
(w) Ledge rock quarries with actual production of less than 25,000 tons per month on a rolling 12 month average, or with actual operation of less than 365 days per 5 year period.
NR 407.03(1)(x)
(x) Industrial sand mines with actual production of less than 2,000 tons per month on a rolling 12 month average.
NR 407.03(1)(y)
(y) Fixed sand and gravel plants and fixed crushed stone plants with capacities of 25 tons per hour or less.
NR 407.03(1)(z)
(z) Portable sand and gravel plants and portable crushed stone plants with capacities of 150 tons per hour or less.
NR 407.03(1m)(a)(a) Any facility that is required to submit an annual emission inventory report under s.
NR 438.03 is exempt from the requirement to obtain an operation permit following notification under par.
(c), where all of the following criteria and requirements are met:
NR 407.03(1m)(a)1.
1. The actual emissions of each air contaminant from the facility do not exceed any of the following levels:
NR 407.03(1m)(a)1.a.
a. 10 tons in any calendar year for each of the following air contaminants: particulate matter, nitrogen oxide, sulfur dioxide, PM
10, carbon monoxide and volatile organic compounds.
NR 407.03(1m)(a)1.c.
c. Any stack-appropriate thresholds for emissions points in columns (c), (d), (e) and (f) of Table A, B or C of ch.
NR 445. If the facility is a source of incidental emissions under s.
NR 445.11, this subdivision only applies to emissions of air contaminants which are listed as substances of concern in Table E of ch.
NR 445.
NR 407.03(1m)(a)2.
2. The facility is not subject to an emission limitation or emission standard under section 111 or 112 of the Act (
42 USC 7411 or
7412) except for a source subject solely to regulations or requirements under section 112 (d) (5) or (r) of the Act (
42 USC 7412 (d) (5) or (r)) or engine certified to meet the emission standards in
40 CFR part 60, subpart IIII or JJJJ for each fuel used.
NR 407.03(1m)(a)3.
3. The owner or operator conducts monitoring and maintains records sufficient to demonstrate compliance with the requirements of this paragraph, including the calculation of annual facility-wide emissions. These records shall be maintained on site for at least 5 years, unless a longer period is required by statute or rule.
NR 407.03(1m)(a)4.
4. If a control device is used to limit actual emissions, the owner or operator uses a compliance monitoring method which is identified in s.
NR 439.055.
NR 407.03(1m)(b)
(b) Any facility that is not required to submit an annual emission inventory report under s.
NR 438.03 is exempt from the requirement to obtain an operation permit where all of the criteria and requirements in par.
(a) 1. to
4. are met.
NR 407.03(1m)(c)1.1. The owner or operator of a facility required to submit an air emission inventory report under s.
NR 438.03 shall notify the department of their intent to operate the facility under the exemption criteria in par.
(a).
NR 407.03(1m)(c)2.
2. Any existing permit shall remain in effect until the permit is revoked or coverage under a general or registration permit is withdrawn. A notification under subd.
1. shall serve as a request for revocation of an individual permit or withdrawal from coverage under a general or registration permit.
NR 407.03(1m)(c)3.
3. A notification under subd.
1. shall serve as a request for withdrawal of any pending permit application.
NR 407.03 Note
Note: An owner or operator exempt under this subsection is responsible for complying with all other applicable requirements in chs.
NR 400 to
499.
NR 407.03(1s)(a)(a)
Eligibility. A facility that is a natural minor source is exempt from the requirement to obtain an operation permit.
NR 407.03(1s)(b)1.1. An owner or operator claiming to be exempt under this subsection shall maintain records adequate to show it meets all criteria under the definition of a natural minor source. Emission calculations adequate to determine eligibility with this exemption shall be maintained and made available to a department representative if requested.
NR 407.03(1s)(b)2.
2. In addition to monitoring and recordkeeping requirements contained in any construction permit issued to the source under ch.
NR 406, the owner or operator shall maintain records sufficient to demonstrate compliance with all other applicable requirements in chs.
NR 400 to
499.
NR 407.03(1s)(c)1.1. An owner or operator claiming exemption under this subsection and who has an existing permit or who has submitted a permit application under this chapter or under ch.
NR 406, shall notify the department of an intent to operate under this exemption.
NR 407.03(1s)(c)2.
2. Any existing permit issued under this chapter shall remain in effect until the permit is revoked or coverage under a general or registration permit is withdrawn at the request of the owner or operator.
NR 407.03(1s)(c)3.
3. A notification under subd.
1. shall serve as a request for revocation of any permits issued under this chapter and for withdrawal of any pending operation permit application submitted under this chapter.
NR 407.03(1s)(d)
(d)
Schedule. The owner or operator shall apply for an operation permit in accordance with the requirements of this chapter if any of the following affects the source's ability to remain a natural minor source:
NR 407.03(1s)(d)4.
4. Other emission information indicating that the source is not a natural minor source becomes available.
NR 407.03 Note
Note: An owner or operator exempt under this subsection is responsible for complying with all applicable requirements in chs.
NR 400 to
499, including construction permit requirements identified in ch.
NR 406 and all conditions contained in a permit issued under ch.
NR 406.
NR 407.03 Note
Note: The exemption in this subsection does not preclude the owner or operator of a natural minor source from requesting, and the Department from issuing, an operation permit as allowed under s.
285.60 (2) (b), Stats.
NR 407.03 Note
Note: The Small Business Environmental Assistance Program at dnr.wi.gov may be contacted for more information on applicability and compliance determinations related to the requirements in chs.
NR 400 to
499.
NR 407.03(2)
(2) General category of exempt sources. In addition to the specific categories of exempt sources identified in sub.
(1), no operation permit is required for a direct source if the source is not a part 70 source or an affected source and all of the following requirements are met:
NR 407.03(2)(a)
(a) The maximum theoretical emissions from the source for sulfur dioxide or carbon monoxide do not exceed 9.0 pounds per hour for each air contaminant.
NR 407.03(2)(b)
(b) The maximum theoretical emissions from the source for particulate matter, nitrogen oxides or volatile organic compounds do not exceed 5.7 pounds per hour for each air contaminant.
NR 407.03(2)(ba)
(ba) The maximum theoretical emissions from the source for PM
10 do not exceed 3.4 pounds per hour.
NR 407.03(2)(be)
(be) The maximum theoretical emissions from the source for PM
2.5 do not exceed 2.2 pounds per hour.
NR 407.03(2)(bm)
(bm) The maximum theoretical emissions from the source for lead do not exceed 0.13 pounds per hour.
NR 407.03(2)(d)
(d) The maximum theoretical emissions from the source for any hazardous air contaminant listed in Table A, B or C of s.
NR 445.07 do not exceed the emission rate listed in the table for the hazardous air contaminant for the respective stack height. For the purposes of determining emissions under this paragraph, the owner or operator of a source is not required to consider emissions of hazardous air contaminants associated with agricultural waste.
NR 407.03 Note
Note: Par. (d) is shown as affected by
2011 Wis. Act 122. On May 24, 2011, the Joint Committee for the Review of Administrative Rules (JCRAR) adopted a motion under s.
227.26 (2) (d), Stats., that suspended s.
NR 407.03 (2) (d) in part as shown below. Pursuant to s.
227.26 (2) (f), Stats., JCRAR introduced 2011 Assembly Bill 195 and 2011 Senate Bill 138, in support of the JCRAR suspension. 2011 Senate Bill 138 was enacted, effective March 22, 2012, resulting in in the repeal of the rules as suspended by the May 24, 2011 JCRAR motion, as provided in s.
227.26 (2) (i), Stats., and creating s.
285.28, Stats., as set forth below.
NR 407.03 Note
NR 407.03 (2) (d) The maximum theoretical emissions from the source for any hazardous air contaminant listed in Table A, B or C of s.
NR 445.07 do not exceed the emission rate listed in the table for the hazardous air contaminant for the respective stack height. For the purposes of determining emissions under this paragraph, the owner or operator of a source is not required to consider emissions of hazardous air contaminants associated with agricultural waste
prior to July 31, 2011.
NR 407.03 Note
285.28 Agricultural waste; hazardous air contaminants. The department may not regulate the emission of hazardous air contaminants associated with agricultural waste except to the extent required by federal law.
NR 407.03 Note
Note: Owners and operators of facilities emitting less than 3 tons of volatile organic compounds and 5 tons of particulate matter on an annual basis, or who engage in limited or no manufacturing activities, should refer to s.
NR 445.11 prior to determining applicable requirements under this section.
NR 407.03(2)(e)
(e) The source will not have maximum theoretical emissions of any single hazardous air pollutant listed under section 112 (b) of the Act (
42 USC 7412 (b)) that equal or exceed 10 tons per year or cumulative maximum theoretical emissions of all the hazardous air pollutants listed under section 112 (b) of the Act (
42 USC 7412 (b)) that equal or exceed 25 tons per year.
NR 407.03(2)(f)
(f) The source is not subject to an emission limitation or emission standard under section 111 of the Act (
42 USC 7411) excluding engines certified to meet the emission standards in
40 CFR part 60, subpart IIII or JJJJ for each fuel used.
NR 407.03(2)(g)
(g) The source is not subject to an emission limitation or emission standard under section 112 of the Act (
42 USC 7412), excluding section 112 (d) (5) or (r) (
42 USC 7412 (d) (5) or (r)).
NR 407.03(4)
(4) Conditions for specific exemptions. In order to be eligible for a specific exemption under sub.
(1) (ce),
(cm),
(d),
(g),
(gm),
(h),
(o),
(s),
(w) or
(x), the owner or operator of a direct stationary source shall keep and maintain the records required under pars.
(a) to
(f), as applicable. The records shall be kept in a manner that allows the source to accurately calculate the required information on a monthly basis. The owner or operator of a direct stationary source shall begin keeping the records required under pars.
(b) to
(f) no later than January 1, 1994, and the records required under par.
(a) no later than January 1, 1998, or the date that the source commences operation, whichever is later, and maintain them for a minimum of 5 years. After January 1, 1994, any direct stationary source that ever exceeds any level listed in sub.
(1) (d),
(g),
(h),
(o),
(s),
(sm),
(w) or
(x) is not eligible for the exemption under that subsection. After January 1, 1998, any direct stationary source that ever exceeds any level listed in sub.
(1) (ce) or
(cm) is not eligible for the exemption under that subsection. After February 1, 2001, any direct stationary source that ever exceeds any level listed in sub.
(1) (gm) is not eligible for the exemption under that subsection. The records required are as follows:
NR 407.03(4)(a)
(a) To be exempt under sub.
(1) (ce) or
(cm), records of the tons of grain received at the grain storage or processing facility per month.
NR 407.03(4)(b)
(b) To be exempt under sub.
(1) (d), records of the cubic yards of concrete produced by the Portland concrete batch plant per month.
NR 407.03(4)(c)
(c) To be exempt under sub.
(1) (g),
(gm) or
(h), records of the amounts used and VOC content of all VOC containing materials used at the facility per month.
NR 407.03(4)(d)
(d) To be exempt under sub.
(1) (o), records of the number of hours that the laboratory operates, the amounts, VOC content and hazardous air contaminant content of all materials used and the amount, type and sulfur content of all fuels used per month.
NR 407.03(4)(e)
(e) To be exempt under sub.
(1) (s), records of the daily gasoline throughput for the bulk plant.
NR 407.03(4)(f)
(f) To be exempt under sub.
(1) (w) or
(x), records of the tons of material produced at a ledge rock quarry or sand mine per month, or for ledge rock quarries exempt for operating less than 365 days in a 5-year period, records indicating each day that the quarry operates.
NR 407.03 Note
Note: Between January 1, 1994 and January 1, 1998, s.
NR 407.03 (4) contained recordkeeping requirements which were less specific than those set forth in pars. (b) to (f). Compliance with the recordkeeping requirements in this subsection will be assessed based on the administrative rule in effect at the time.
NR 407.03 History
History: Cr.
Register, December, 1984, No. 348, eff. 1-1-85; cr. (2) (bm), r. and recr. (2) (d), am. (2) (e),
Register, September, 1988, No. 393; eff. 10-1-88; am. (1) (a) (intro.), 1. to 3., (b), (g), (h), (o), (2) (a), (b), (bm), (c) 1. and 5., (d) and (e),
Register, May, 1992, No. 437, eff. 6-1-92; am. (1) (intro.), (a) (intro.) and 5., (b) to (e), (2) (intro.), (a) to (c), cr. (1) (sm), (sq) and (u), (2) (f), (g), (3) to (5), r. (2) (c) 1. to 5., r. and recr. (2) (e),
Register, December, 1993, No. 456, eff. 1-1-94; cr. (1) (v) to (z),
Register, June, 1994, No. 462, eff. 7-1-94; am. (1) (sm) (intro.), 1. to 3., r. 5., renum. 6. to 10. to be 5. to 9. and am. 7. and 9.,
Register, September, 1994, No. 465, eff. 10-1-94; am. (2) (d),
Register, December, 1994, No. 468, eff. 1-1-95; am. (1) (intro.), (2) (intro.),
Register, April, 1995, No. 472, eff. 5-1-95; am. (1) (a) 5., r. and recr. (1) (k), r. (3) and (5),
Register, June, 1995, No. 474, eff. 7-1-95; am. (1) (sm) (intro.),
Register, August, 1995, No. 476, eff. 9-1-95; am. (1) (g), (h), (o), (2) (b) and (4),
Register, December, 1995, No. 480, eff. 1-1-96; am. (1) (g), (sm) 9.,
Register, December, 1996, No. 492, eff. 1-1-97; am. (1) (i) and (j),
Register, March, 1997, No. 495, eff. 4-1-97; cr. (1) (km),
Register, September, 1997, No. 501, eff. 10-1-97; cr. (1) (ce), (cm), (t) 4., 5., (3), (4) (a) to (f); am. (1) (s), (sm) (intro.), (t) (intro.), 1. and (4), renum. (1) (t) 4. to be (1) (t) 6. and am.,
Register, December, 1997, No. 504, eff. 1-1-98; am. (1) (g), (h), (o), (2) (intro.), (e) and (g),
Register, October, 1999, No. 526, eff. 11-1-99; cr. (1) (gm), am. (4) (intro.) and (c),
Register, January, 2001, No. 541, eff. 2-1-01;
CR 02-097: am (1) (sm) (intro.) and (2) (d)
Register June 2004 No. 582, eff. 7-1-04;
CR 04-107: r. (1) (c), am. (1) (ce) and (cm)
Register August 2005 No. 596, eff. 9-1-05; correction in (1) (t) 6. made under s. 13.93 (2m) (b) 7., Stats.,
Register August 2005 No. 596;
CR 06-047: cr. (1m)
Register May 2007 No. 617, eff. 6-1-07; corrections in (1) (a) and (b) made under s. 13.93 (2m) (b) 7., Stats.,
Register May 2007 No. 617;
CR 07-076: am. (2) (d)
Register July 2008 No. 631, eff. 8-1-08;
CR 09-020: am. (1) (g), (gm), (h), (o), (sm) (intro.), (sq), (1m) (a) 2., (2) (e), (f), (g), and (4) (intro.)
Register January 2010 No. 649, eff. 2-1-10;
CR 10-050: cr. (2) (be)
Register November 2010 No. 659, eff. 12-1-10;
2011 Wis. Act 122: r. in part (2) (d) eff. 3-22-12; s. 35.17, Stats., correction in (1m) (a) 2.,
Register February 2014 No. 698;
CR 15-005: renum. (1) (u) to (1) (u) (intro.) and am., cr. (1) (u) 1., 2., (1s)
Register November 2015 No. 719, eff. 12-1-15;
CR 19-015: am. (1) (intro.), cr. (1) (a) 4m., (bm), am. (1m) (a) 2., (c) 1., cr. (2) (ba), am. (2) (f), (g)
Register September 2020 No. 777, eff. 10-1-20.
NR 407.04
NR 407.04 Permit application requirements. The owner or operator of an air contaminant source which is not exempt under s.
285.60 (5), Stats., or s.
NR 407.03 shall submit an operation permit application or renewal application, in accordance with s.
NR 407.05, by the dates specified in this section:
NR 407.04(1)
(1) Initial filing dates. Except as provided under subs.
(3) to
(7), the initial operation permit application shall be submitted by one of the following dates:
NR 407.04 Note
Note: Application forms may be obtained from the Department Regional Headquarter or Service Center offices or from the Wisconsin Department of Natural Resources, Bureau of Air Management, PO Box 7921, Madison WI 53707-7921, Attention: operation permits.
NR 407.04(1)(a)
(a) Existing sources, initial application. For initial applications for all existing sources, the date in the appropriate column of Table 1 for part 70 and non-part 70 sources corresponding to the county in which the source is located. Where the location of a source is in 2 or more counties, the date an application is due shall be the latest date listed for any of the counties in which the source is located. Any existing air contaminant source for which an application is submitted requesting that it be made a synthetic minor source is a part 70 source until a permit making that source a synthetic minor source is issued and, except as allowed in sub.
(3), is subject to the filing dates listed for part 70 sources. If a source submits an application on or before the date specified in Table 1 and the department determines that the application is incomplete, the source shall have 30 days from the date that the department notifies the source of the incompleteness determination to complete the application.
NR 407.04(1)(b)1.1. In accordance with s.
285.62 (11) (b) 2., Stats., for new or modified sources for which a construction permit is required and which apply for a construction permit after November 15, 1992, the date that the application for the construction permit is filed.
NR 407.04(1)(b)2.
2. For new or modified sources for which a construction permit is required and which applied for a construction permit before November 15, 1992, a date at least 120 days prior to the expiration date of the construction permit.
NR 407.04(1)(b)3.
3. For new or modified sources for which no construction permit is required, a date before the source commences construction or modification. For purposes of determining the date of commencement of construction or modification, the exclusions provided in s.
NR 406.03 (1e) shall apply.
