Skip navigation Wisconsin State Legislature
This is the preview version of the Wisconsin State Legislature site.
Please see http://docs.legis.wisconsin.gov for the production version.
Up
NR 237.05(2) (2) Direct dischargers. The following requirements are applicable to any facility which is a direct discharger and which uses or generates cyanide:
NR 237.05(2)(a) (a) If all waste streams containing cyanide are diverted to a cyanide destruction unit and if the effluent from the cyanide destruction unit is discharged to a biological treatment system, self monitoring shall be conducted after cyanide treatment and before dilution with other streams, except as provided in par. (b).
NR 237.05(2)(b) (b) Self monitoring may be conducted at the final effluent discharge point if 3 adjustments are made:
NR 237.05(2)(b)1. 1. The daily maximum cyanide limitation is multiplied by 0.18;
NR 237.05(2)(b)2. 2. The 30-day maximum cyanide limitation is multiplied by 0.35; and
NR 237.05(2)(b)3. 3. The daily and 30-day maximum cyanide limitations are further adjusted according to the ratio of the flow of the waste streams containing cyanide to the total process wastewater discharge flow.
NR 237.05(2)(c) (c) If all waste streams containing cyanide are not treated in a cyanide destruction unit or if the effluent from the cyanide destruction unit is not discharged to a biological treatment system, self monitoring shall be conducted at the final effluent discharge point as provided in par. (b).
NR 237.05(3) (3) Discharges to a publicly owned treatment works. The following requirements are applicable to any facility which discharges to a POTW and which uses or generates cyanide:
NR 237.05(3)(a) (a) If all waste streams containing cyanide are diverted to a cyanide destruction unit, self monitoring shall be conducted after cyanide treatment and before dilution with other streams, except as provided in par. (b).
NR 237.05(3)(b) (b) Self monitoring may be conducted at the final effluent discharge point if the daily and 30-day maximum cyanide standards are adjusted according to the ratio of the flow of the waste streams containing cyanide to the total process wastewater discharge flow.
NR 237.05(3)(c) (c) If all waste streams containing cyanide are not treated, self monitoring shall be conducted at the final effluent discharge point as provided in par. (b).
NR 237.05 History History: Cr. Register, May, 1990, No. 413, eff. 6-1-90.
NR 237.06 NR 237.06 Dilution. Dilution to meet the standards set forth in this chapter may not be practiced.
NR 237.06 History History: Cr. Register, May, 1990, No. 413, eff. 6-1-90.
NR 237.07 NR 237.07 Compliance dates.
NR 237.07(1) (1) Any existing source subject to this chapter which discharges to waters of the state shall achieve:
NR 237.07(1)(a) (a) The effluent limitations representing BPT by July 1, 1977; and
NR 237.07(1)(b) (b) The effluent limitations representing BAT by July 1, 1984.
NR 237.07(2) (2) Any new source subject to this chapter which discharges to waters of the state shall achieve NSPS at the commencement of discharge.
NR 237.07(3) (3) Any existing source subject to this chapter which introduces process wastewater pollutants into a POTW shall achieve PSES by October 27, 1986.
NR 237.07(4) (4) Any new source subject to this chapter which introduces process wastewater pollutants into a POTW shall achieve PSNS at the commencement of discharge.
NR 237.07 History History: Cr. Register, May, 1990, No. 413, eff. 6-1-90.
NR 237.08 NR 237.08 Effluent limitations representing the degree of effluent reduction attainable by the application of the best practicable control technology currently available.
NR 237.08(1)(1)  Existing source. Except as provided in 40 CFR 125.30 to 125.32, any existing source subject to this chapter shall achieve the effluent limitations set forth in subs. (2), (3) and (4) representing the degree of effluent reduction attainable by the application of BPT.
NR 237.08(2) (2) Biological oxygen demand and chemical oxygen demand.
NR 237.08(2)(a)(a) Except as provided in par. (c), the limitation for the daily average mass of BOD5 and COD for any calendar month shall be calculated by multiplying the long term daily average raw waste load by a variability factor and the difference between 1 and the required fractional reduction as given in the following table: - See PDF for table PDF
NR 237.08(2)(b) (b) The limitations for BOD5 and COD shall be expressed in mass per unit time.
NR 237.08(2)(c) (c) Extraction operations and mixing, compounding, and formulation operations are not required to reduce the maximum 30-day average BOD5 concentration to less than 45 mg/l or reduce the maximum 30-day average COD concentration to less than 220 mg/l.
NR 237.08(2)(d) (d)
NR 237.08(2)(d)1.1. For fermentation operations, calculation of raw waste loads of BOD5 and COD shall exclude any waste load associated with separable mycelia and solvents in those waste loads, except that residual amounts of solvents remaining after solvent recovery, separate disposal, or reuse may be included in the raw waste load. Removal, disposal, and reuse includes physical separation and removal of separable mycelia, recovery of solvents from waste streams, incineration of concentrated solvent waste streams, incineration of tar still bottoms, and broth concentration for disposal other than to the treatment system.
NR 237.08(2)(d)2. 2. For extraction, chemical synthesis, and mixing, compounding, and formulation operations, calculation of raw waste loads of BOD5 and COD shall exclude any waste load associated with solvents in those waste loads, except that residual amounts of solvents remaining after solvent recovery, separate disposal, or reuse may be included in the raw waste load. Removal, disposal, and reuse includes recovery of solvents from waste streams and incineration of concentrated solvent waste streams and incineration of tar still bottoms.
NR 237.08(3) (3) Total suspended solids. The TSS BPT effluent limitation shall be calculated by multiplying the BOD5 limitation, as calculated in sub. (2), by 1.7.
NR 237.08(4) (4) Cyanide and pH. The following limitations for cyanide and pH apply: - See PDF for table PDF
NR 237.08 Note (1) This applies only to those plants using or generating cyanide and to discharges not resulting from research.
NR 237.08 Note (2) Within the range of 6.0 to 9.0.
NR 237.08 History History: Cr. Register, May, 1990, No. 413, eff. 6-1-90.
NR 237.09 NR 237.09 Effluent limitations representing the degree of effluent reduction attainable by the application of the best available technology economically achievable.
NR 237.09(1)(1) Except as provided in 40 CFR 125.30 to 125.32 and sub. (2), any existing source subject to this chapter which uses or generates cyanide shall achieve the following effluent limitations representing the degree of effluent reduction attainable by the application of BAT: - See PDF for table PDF
NR 237.09(2) (2) This section does not apply to discharges resulting from pharmaceutical research at facilities which do not manufacture pharmaceuticals.
NR 237.09 History History: Cr. Register, May, 1990, No. 413, eff. 6-1-90.
NR 237.10 NR 237.10 New source performance standards.
NR 237.10(1)(1) Except as provided in sub. (2), any new source subject to this chapter shall achieve the following standards: - See PDF for table PDF
NR 237.10(2) (2) This section does not apply to discharges resulting from
pharmaceutical research at facilities which do not manufacture pharmaceuticals.
NR 237.10 History History: Cr. Register, May, 1990, No. 413, eff. 6-1-90.
NR 237.11 NR 237.11 Pretreatment standards for existing sources.
NR 237.11(1)(1) Except as provided in ss. NR 211.13 and 211.14 and sub. (2), any existing source subject to this chapter which introduces pollutants into a POTW and which uses or generates cyanide shall comply with ch. NR 211 and achieve the following PSES: - See PDF for table PDF
NR 237.11(2) (2) This section does not apply to discharges resulting from pharmaceutical research at facilities which do not manufacture pharmaceuticals.
NR 237.11 History History: Cr. Register, May, 1990, No. 413, eff. 6-1-90.
NR 237.12 NR 237.12 Pretreatment standards for new sources.
NR 237.12(1)(1) Except as provided in s. NR 211.13 and sub. (2), any existing source subject to this chapter which introduces pollutants into a POTW and which uses or generates cyanide shall achieve the standards set forth in s. NR 237.11.
NR 237.12(2) (2) This section does not apply to discharges resulting from pharmaceutical research at facilities which do not manufacture pharmaceuticals.
NR 237.12 History History: Cr. Register, May, 1990, No. 413, eff. 6-1-90.
NR 237.13 NR 237.13 Effluent limitations representing the degree of effluent reduction attainable by the application of the best conventional pollutant control technology.
NR 237.13(1)(1) Except as provided in 40 CFR 125.30 to 125.32 and sub. (2), any existing source subject to this chapter shall achieve the effluent limitations set forth in s. NR 237.09 for BOD5, TSS, and pH.
NR 237.13(2) (2) This section does not apply to discharges resulting from pharmaceutical research at facilities which do not manufacture pharmaceuticals.
NR 237.13 History History: Cr. Register, May, 1990, No. 413, eff. 6-1-90.
NR 237.13 Note Note: The Wisconsin administrative code corresponds to the code of federal regulations as cross referenced in the following table: - See PDF for table PDF
Down
Loading...
Loading...
Published under s. 35.93, Stats. Updated on the first day of each month. Entire code is always current. The Register date on each page is the date the chapter was last published.